A Subsidiary of

0

000

Most Widely Accepted and Trusted

ICC-ES Report ESR-1573 Reissued 06/2015

This report is subject to renewal 06/2016.

ICC-ES | (800) 423-6587 | (562) 699-0543 | www.icc-es.org

ICC-ES Evaluation Reports are not to be construed as representing aesthetics or any other attributes not specifically addressed, nor are they to be construed as an endorsement of the subject of the report or a recommendation for its use. There is no warranty by ICC Evaluation Service, LLC, express or implied, as to any finding or other matter in this report, or as to any product covered by the report.

Copyright © 2015

“2014 Recipient of Prestigious Western States Seismic Policy Council (WSSPC) Award in Excellence”

Look for the trusted marks of Conformity!

DIVISION: 06 00 00—WOOD, PLASTICS AND COMPOSITES SECTION: 06 53 00—PLASTIC DECKING

REPORT HOLDER:

UFP VENTURES II, INC.

1801 EAST LESSARD STREET PRAIRIE DU CHIEN, WISCONSIN 53821

EVALUATION SUBJECT: SOLID EDGE WOOD COMPOSITE PLASTIC DECK BOARDS;

SLOTTED EDGE WOOD COMPOSITE PLASTIC DECK BOARDS; and FASTENER SYSTEMS: EQUATOR® HIDDEN FASTENER SYSTEM AND TREX

HIDEAWAY® PLASTIC HIDDEN FASTENER SYSTEM

ICC-ES Evaluation Reports are not to be construed as representing aesthetics or any other attributes not specifically addressed, nor are they to be construed as an endorsement of the subject of the report or a recommendation for its use. There is no warranty by ICC Evaluation Service, LLC, express or implied, as to any finding or other matter in this report, or as to any product covered by the report.

Copyright © 2015 Page 1 of 10 1000

ICC-ES Evaluation Report ESR-1573 Reissued June 2015 This report is subject to renewal June 2016.

www.icc-es.org | (800) 423-6587 | (562) 699-0543 A Subsidiary of the International Code Council ®

DIVISION: 06 00 00—WOOD, PLASTICS, AND COMPOSITES

Section: 06 53 00—Plastic Decking REPORT HOLDER: UFP VENTURES II, INC. 1801 EAST LESSARD STREET PRAIRIE DU CHIEN, WISCONSIN 53821 (608) 326-0900 www.ufpi.com EVALUATION SUBJECT:

SOLID EDGE WOOD COMPOSITE PLASTIC DECK BOARDS:

LATITUDES CAPTIVA™—SOLID EDGE (ALSO KNOWN AS LATITUDES CAPRICORN®—SOLID EDGE AND WOLF-SOLID EDGE);

LATITUDES CAPTIVA™—SOLID EDGE 4-LOBED (ALSO KNOWN AS LATITUDES CAPRICORN®—SOLID EDGE 4-LOBED AND WOLF-SOLID EDGE 4-LOBED);

LATITUDES CLASSIC—SOLID EDGE (ALSO KNOWN AS VERANDA®—SOLID EDGE AND LATITUDES WAVE-SOLID EDGE);

LATITUDES INTREPIDTM—SOLID EDGE, LATITUDES® MARINE BOARD (ALSO KNOWN AS VERANDA® MARINE BOARD);

STYLE SELECTIONS—SOLID EDGE 4-LOBED;

STYLE SELECTIONS—SOLID EDGE 3-LOBED;

VERANDA—SOLID EDGE 3-LOBED (ALSO KNOWN AS PACIFIC SERIES-SOLID EDGE 3-LOBED, HP SOLID EDGE 3-LOBED AND TROPIC SOLID EDGE 3-LOBED);

DECKORATORS CLASSIC—SOLID EDGE (ALSO KNOWN AS VISTA—SOLID EDGE AND HERITAGE—SOLID EDGE); and

EVERX™ (ALSO KNOWN AS LATITUDES WAVE SOLID EDGE 4-LOBED).

SLOTTED EDGE WOOD COMPOSITE PLASTIC DECK BOARDS:

LATITUDES CAPTIVA™—SLOTTED (ALSO KNOWN AS LATITUDES CAPRICORN®—SLOTTED AND WOLF-SLOTTED);

LATITUDES CLASSIC—SLOTTED (ALSO KNOWN AS VERANDA®—SLOTTED 2011);

LATITUDES INTREPIDTM—SLOTTED, LATITUDES WAVE—SLOTTED (ALSO KNOWN AS VERANDA—SLOTTED 2013);

STYLE SELECTIONS—SLOTTED 4-LOBED;

STYLE SELECTIONS—SLOTTED 3-LOBED;

VERANDA SLOTTED EDGE 3-LOBED (ALSO KNOWN AS PACIFIC SERIES—SLOTTED EDGE 3-LOBED, HP SLOTTED EDGE 3-LOBED AND TROPIC SLOTTED EDGE 3-LOBED); and

DECKORATORS CLASSIC SLOTTED (ALSO KNOWN AS VISTA SLOTTED AND HERITAGE SLOTTED).

FASTENER SYSTEMS: EQUATOR® HIDDEN FASTENER SYSTEM AND TREX HIDEAWAY® PLASTIC HIDDEN FASTENER SYSTEM

1.0 EVALUATION SCOPE

Compliance with the following codes:

2015, 2012, 2009 and 2006 International Building Code® (IBC)

2015, 2012, 2009 and 2006 International Residential Code® (IRC)

2013 Abu Dhabi International Building Code (ADIBC)† †The ADIBC is based on the 2009 IBC. 2009 IBC code sections referenced in this report are the same sections in the ADIBC.

Properties evaluated:

Structural

Durability

Surface-burning characteristics

2.0 USES

The wood plastic composite deck boards described in this report are limited to exterior use as deck boards for balconies, porches, stair treads, and decks of buildings of Type V-B (IBC) construction and dwellings constructed in accordance with the IRC. Deck boards for use as stair treads are limited to the deck boards in Section 4.3.

3.0 DESCRIPTION

3.1 General:

The deck boards described in this report are wood thermoplastic composite lumber (WTCL) consisting of a minimum of 50 percent wood flour and a maximum of 50 percent high-density polyethylene and other processing additives. The deck boards are manufactured by an extrusion process in accordance with the approved quality assurance manual in four colors (redwood, cedar, gray and walnut). Latitudes Capricorn, Latitudes Captiva, and Style Selections have a 1/32-inch-thick (0.8 mm) polyethylene

ESR-1573 | Most Widely Accepted and Trusted Page 2 of 10

coating embossed on top. The deck boards are either solid or slotted.

3.2 Deck Boards:

3.2.1 Solid Edge (Unslotted) Deck Boards: See Figure 1 for dimensions of solid edge deck boards.

3.2.2 Slotted Edge Deck Boards: The boards are slotted on each side for the use a hidden fastener system. The three types of hidden fastener systems recognized in this report are the Equator Hidden Fastener System, Stowaway Hidden Fastener System and the Trex Hideaway Plastic Hidden Fastener System. See Figure 2 for dimensions of slotted deck boards.

3.2.3 Fastener Systems:

3.2.3.1 Equator Hidden Fastener System: The Equator Hidden Fastener System consists of a plastic clip made of polypropylene copolymer and No. 8 by 2-inch-long (51 mm) square drive stainless steel screws with 0.22-inch (5.6 mm) head diameters. The system is used with the slotted deck boards listed in Section 3.2.2. See Figure 3 for dimension of fastener system.

3.2.3.2 Trex Hideaway Plastic Hidden Fastener System: The Trex Hideaway Plastic Hidden Fastener System consists of a plastic clip and a No. 8 by 1.625-inch-long (41.3 mm) stainless steel flathead screw. The system is an alternative fastener system for the Style Selections– Slotted.

3.2.3.3 Stowaway Hidden Fastener System (alternative hidden fastener system only for the Veranda Slotted Edge 3-Lobed deck boards): The Stowaway Hidden Fastener System consists of a plastic clip measuring approximately 11/4 inch by 3/4 inch and a No. 7 by 1.625-inch-long (41.3 mm) stainless steel screw. See Figure 4 for a profile of the fastener system.

3.3 Durability:

When subjected to weathering, insect attack including Formosan termites, and other decaying elements, the material used to manufacture the deck board products is equivalent in durability to preservative-treated or naturally durable lumber when used in locations described in Section 2.0 of this report. The deck boards have been evaluated for use within a temperature range of -20°F to 125°F (-29°C to 52°C).

3.4 Surface-burning Characteristics:

When tested in accordance with ASTM E84, the deck board products have a flame-spread index no greater than 200.

4.0 DESIGN AND INSTALLATION

4.1 General:

Installation of deck boards must comply with this report and the manufacturer’s published installation instructions. The manufacturer’s published installation instructions must be available at the jobsite at all times during installation. When the manufacturer’s published installation instructions differ from this report, this report governs.

4.2 Deck Boards:

4.2.1 Structural: The wood plastic composite deck boards have an allowable capacity, when installed at a maximum center-to-center spacing of the supporting construction as prescribed in Table 1. A minimum of ¼-inch (6.4 mm) side gapping must be provided between the decking materials and any permanent structure or post.

4.2.2 Fasteners:

4.2.2.1 Solid deck boards: The solid deck boards described in Section 3.2.1 must be attached at each joist using two No. 7 by 21/2-inch-long (64 mm) corrosion-resistant wood screws. The maximum allowable fastener head pull-through load is 296 lbf (1348 N) per fastener. Fasteners located within 11/2 inch (38 mm) of board ends must be predrilled.

4.2.2.2 Slotted deck boards:

4.2.2.2.1 Installation of the Equator Hidden Fastener System: The slotted deck boards described in Section 3.2.2 must be attached at each joist using the Equator Hidden Fastener System. The fastener wings must remain level with the joist for the boards to fit correctly. The deck boards must be attached to the outside and inside edges of the deck with No. 8 by 2-inch-long (51 mm) corrosion-resistant traditional screws at 16 inches on center. Fasteners located within 11/2 inches (38 mm) of board ends must be predrilled. When installed in accordance with this section, the boards have an allowable capacity of 80 psf (3830 Pa). See Figure 3.

4.2.2.2.2 Installation of the Trex Hideaway Plastic Hidden Fastener System: The Trex Hideaway Plastic Hidden Fastener System as described in Section 3.2.3.2 is an alternative hidden fastener system for the Style Selections–Slotted deck boards. When the boards are installed on 90 degrees to supporting joists for a maximum span of 16 inches (406 mm) on center using the Trex Hideaway Plastic Hidden Fastener System installed at each joist, the boards have an allowable capacity of 100 psf (4788 Pa).

4.2.2.2.3 Installation of the Stowaway Hidden Fastener System: The Stowaway Hidden Fastener System, as described in Section 3.2.3.3, is an alternative hidden fastener system for the Veranda—Slotted Edge 3-lobed deck boards. When the boards are installed 90 degrees to a supporting joist for a maximum span of 16 inches (406 mm) on center and the Stowaway Hidden Fasteners are installed at each joist, the boards have an allowable capacity of 100 psf (4788 Pa).

4.2.2.2.4 Deck Boards to Rim Joists: The boards must be attached to rim joists with one No. 8 or No. 9 by 21/2-inch-long (64 mm) corrosion-resistant screw spaced at 16 inches (406 mm) on center.

4.3 Deck Boards Used as Stair Treads:

The wood plastic deck boards, when used as stair treads, are satisfactory to resist the code prescribed concentrated load of 300 lbf (1.33 kN) when installed at a maximum center-to-center spacing of the supporting construction as shown in Table 2. As an alternate, the Veranda and Style Selections Solid Edge and Slotted Edge 3-lobed deck boards can be installed as shown in Figure 5 or 6.

5.0 CONDITIONS OF USE

The wood plastic composite deck boards described in this report comply with, or are suitable alternatives to what is specified in, those codes listed in Section 1.0 of this report, subject to the following conditions:

5.1 The deck boards listed in Table 1 are limited to exterior use as deck boards for balconies, porches, stair treads, and decks of buildings of Type V-B (IBC) construction and dwellings constructed in accordance with the IRC.

5.2 The deck boards listed in Table 2 are limited to exterior use as deck boards only for balconies, porches and decks of buildings of Type V-B (IBC) construction and dwellings constructed in accordance with the IRC.

ESR-1573 | Most Widely Accepted and Trusted Page 3 of 10

5.3 Installation must comply with this report, the manufacturer’s published installation instructions and the applicable code. Only those fasteners and fastener configurations described in this report have been evaluated for the installation of deck boards mentioned in Section 4.2.2 of this report. In the event of conflict between this report and the manufacturer’s published installation instructions, this report governs.

5.4 The use of deck boards as a component of a fire-resistance-rated assembly is outside the scope of this report.

5.5 The compatibility of the fasteners with the supporting construction, including chemically treated wood, is outside the scope of this report.

5.6 Adjustment factors outlined in the AF&PA National Design Standard and applicable codes must not apply to the allowable capacity and maximum spans for deck boards.

5.7 The deck boards must be directly fastened to supporting construction. Where required by the code official, engineering calculations and construction documents consistent with this report must be submitted for approval. The calculations must verify that the supporting construction complies with the applicable building code requirements and is adequate to resist the loads imparted upon it by the

products and systems discussed in this report. The documents must contain details of the attachment to the supporting structure consistent with the requirements of this report. The documents must be prepared by a registered design professional where required by the statutes of the jurisdiction in which the project is to be constructed.

5.8 The deck boards are produced by UFP Ventures II in Prairie du Chien, Wisconsin, under a quality-control program with inspections by ICC-ES.

6.0 EVIDENCE SUBMITTED

Data in accordance with the ICC-ES Acceptance Criteria for Deck Board Span Ratings and Guardrail Systems (Guards and Handrails) (AC174), dated January 2012 (editorially revised December 2014).

7.0 IDENTIFICATION

The deck boards described in this report must be identified by a stamp on each individual piece bearing the manufacturer’s name (UFP Ventures II, Inc.) or the company name, the product name, the span rating for use as deck board, the allowable span and allowable load for use as deck board or as a stair tread, and the ICC-ES evaluation report number (ESR-1573).

ESR-1573 | Most Widely Accepted and Trusted Page 4 of 10

TABLE 1—DECK BOARD SPAN RATINGS3

DECK BOARD ALSO KNOWN AS:

DECK BOARD INSTALLED AT X° TO SUPPORTING

JOIST:

MAXIMUM SPAN (in)1

ALLOWABLE CAPACITY

(lbf/ft2)2

Solid Edge Deck Boards

Latitudes Captiva—Solid Edge Latitudes Capricorn—Solid Edge Wolf-Solid Edge

45° 12 100

90° 16 100

Latitudes Captiva—Solid Edge 4-Lobed

Latitudes Capricorn—Solid Edge 4-Lobed

Wolf—Solid Edge 4-Lobed

45° 12 100

90° 16 100

Latitudes Classic—Solid Edge Veranda—Solid Edge Latitudes Wave-Solid Edge

45° 12 100

90° 16 100

Latitudes Intrepid—Solid Edge — 45° 12 100

90° 16 100

Latitudes Marine Board Veranda Marine Board 45° 16 100

90° 24 100

Style Selections—Solid Edge 4- Lobed

— 45° 12 100

90° 16 100

Style Selections—Solid Edge 3- Lobed

— 45° 12 100

90° 16 100

EverX Latitudes Wave-Solid Edge 4-Lobed 45° 12 100

90° 16 100

Veranda-Solid Edge 3-Lobed Pacific Series-Solid Edge 3-Lobed, HP-Solid Edge 3-Lobed Tropic Solid Edge 3-Lobed

45° 12 100

90° 16 100

DecKorators Classic—Solid Edge Vista- Solid Edge Heritage - Solid Edge

45° 12 100

90° 16 100

Slotted Deck Boards

Latitudes Captiva—Slotted Latitudes Capricorn—Slotted Wolf-Slotted

45° 12 100

90° 16 100

Latitudes Classic—Slotted Veranda—Slotted 2011 45° 12 100

90° 16 100

Latitudes Intrepid—Slotted — 45° 12 100

90° 16 100

Latitudes Wave—Slotted Veranda—Slotted 2013 45° 12 100

90° 16 100

Style Selections—Slotted 4-Lobed — 45° 12 100

90° 16 100

Style Selections—Slotted 3-Lobed — 45° 12 100

90° 16 100

Veranda—Slotted Edge 3-Lobed Pacific Series—Slotted Edge 3-Lobed HP-Slotted Edge 3-Lobed Tropic-Slotted Edge 3-Lobed

45° 12 100

90° 16 100

DecKorators Classic—Slotted Vista—Slotted Heritage—Slotted

45° 12 100

90° 16 100

For SI: 1 inch = 25.4 mm; 1 lbf/ft2 = 47.9 Pa. 1Maximum span is measured center-to-center perpendicular, of the supporting construction. 2Maximum allowable capacity is adjusted for durability. No further increases are permitted.

ESR-1573 | Most Widely Accepted and Trusted Page 5 of 10

TABLE 2—MAXIMUM STAIR TREAD SPANS

DECK BOARD ALSO KNOWN AS: SPAN CONDITION MAXIMUM SPAN

(in)1,2

Solid Edge Deck Board

Latitudes Marine Board Veranda Marine Board One-span 12

Latitudes Captiva—Solid Edge Latitudes Capricorn—Solid Edge Wolf- Slotted

Two-span 8 Latitudes Captiva—Solid Edge 4-Lobed

Latitudes Capricorn—Solid Edge 4-Lobed Wolf—Solid Edge 4-Lobed

Latitudes Classic—Solid Edge Veranda—Solid Edge Latitudes Wave-Solid Edge

Latitudes Intrepid—Solid Edge —

EverX Latitudes Wave-Solid Edge 4-Lobed Two-span 8

Style Selections—Solid Edge 4-Lobed — Two-span 8

Style Selections—Solid Edge 3-Lobed — Fully Supported NA4

Veranda—Solid Edge 3-Lobed Fully Supported NA4

DecKorators Classic—Solid Edge Two-span 8

Slotted Deck Board

Latitudes Classic—Slotted Veranda—Slotted 2011

Two-span 8

Latitudes Intrepid—Slotted —

Latitudes Captiva—Slotted Latitudes Capricorn—Slotted Wolf-Slotted

Style Selections—Slotted Edge 4-Lobed —

Style Selections—Slotted Edge 3-Lobed — Fully Supported NA3

Veranda —Slotted 3-Lobed Pacific Series—Slotted 3-Lobed HP-Slotted Edge 3-Lobed Tropic-Slotted Edge 3-Lobed

Fully Supported NA3

DecKorators Classic—Slotted Vista- Slotted Heritage-Slotted

Two-span 8

For SI: 1 inch = 25.4 mm; 1 lbf/ft2 = 47.9 Pa. 1Maximum span is measured center-to-center perpendicular, of the supporting construction. 2Deck boards installed at 90° to supporting stringer. 3 See Figures 5 and 6.

E

ESR-1573 | M

LATIT(Also known a

LATIT(Also kn

La

LATIT

LA(Also k

FIGURE

Most Widely Acc

TUDES CAPTIVAas Latitudes Cap

Wolf—Solid

TUDES CLASSICown as Veranda

atitudes Wave—

UDES INTREPID

ATITUDES MARnown as Verand

1—SOLID EDG

cepted and Tru

A—SOLID EDGEpricorn—Solid E

d Edge)

C—SOLID EDGEa—Solid Edge a

—Solid Edge)

D—SOLID EDGE

RINE BOARD da Marine Boar

GE DECK BOAR

usted

E Edge and

E and

E

d)

DS

LAT(Also kno

LAT(Als

LAT

FIGUR

TITUDES CAPTIown as Latitudes

and Wolf—S

TITUDES CLASSo known as Ver

TITUDES INTREP

RE 2—SLOTTED

Pa

VA—SLOTTEDs Capricorn—SSlotted)

SIC—SLOTTEDranda—Slotted)

PID—SLOTTED

D DECK BOARD

age 6 of 10

lotted

)

D

DS

E

ESR-1573 | M

STYLE S

FIGURE 1—SO

Most Widely Acc

EverX

ELECTIONS—S

OLID EDGE DEC

cepted and Tru

X

SLOTTED 4-LOB

CK BOARDS (co

usted

BED

ontinued)

LA

STYLE SE

VE

FIGURE 2—

ATITUDES WAV

ELECTIONS—SO

RANDA—SLOT

—SLOTTED EDG

Pa

VE—SLOTTED

OLID EDGE 4-LO

TTED 3-LOBED

GE DECK BOAR

age 7 of 10

OBED

RDS (continuedd)

E

ESR-1573 | M

FIGU

Most Widely Acc

URE 1—SOLID D(continu

cepted and Tru

DECK BOARDS ed)

usted

FIGURRE 2—SLOTTED(continu

Pa

D DECK BOARDued)

age 8 of 10

DS

E

ESR-1573 | MMost Widely Acccepted and Tru

FIGUR

FIGURE

usted

RE 3—EQUATO

E 4—STOWAWA

R HIDDEN FAST

Back

AY HIDDEN FAS

TENER SYSTEM

STENER SYSTE

M

EM

Paage 9 of 10

E

ESR-1573 | M

F

F

Most Widely Acc

FIGURE 5—VER

FIGURE 6—VER

cepted and Tru

RANDA AND ST

RANDA AND ST

usted

TYLE SELECTIO

TYLE SELECTIO

ONS 3-LOBED D

ONS 3-LOBED D

DECK BOARDS U

DECK BOARDS U

USED AS A STA

USED AS A STA

Pag

AIR TREAD

AIR TREAD

ge 10 of 10